united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 202 kmx miniature -105 c kmx series the kmx is the new long life, low impedance series from united chemi-con. these capacitors have a load life of 8,000 to 10,000 hours at 105 c with the full rated ripple current applied and a voltage range up to 450 volts. the kmx capacitors are ideal for use in electronic ballasts or any other high voltage application where a very long lifetime is required. the kmx series capacitors are non-solvent proof and are not recommended when halogenated cleaning solvents are used. refer to the mini-glossary for recommended cleaning conditions. miniature low impedance long life for electronic ballasts 105 c maximum temperature radial lead terminals. capacitance range: 3.3 to 680 f. voltage range: 160 to 450vdc. operating temperature range: 40 cto 105 c for 160 to 400v; 25 cto 105 c for 450v. leakage current: 0.1cv 40? after 1 minute or 0.03cv 40? after 5 minutes for 1,000cv or less; 0.04cv 100? after 1 minute or 0.02cv 25? after 5 minutes for more than 1,000cv at 20 c. standard capacitance tolerance: 20% nominal case size (d l): 10 20mm to 18 60mm. rated lifetime: 8,000 to 10,000 hours at 105 c with the rated ripple current applied, depending on case size. summary of specifications .com .com .com 4 .com u datasheet
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 203 kmx series kmx miniature -105 c kmx specifications item operating temperature range 40 to 105 c for 160 to 400vdc; 25 to 105 c for 450vdc 160 to 450vdc rated voltage range capacitance range 3.3 to 680 f capacitance tolerance 20% ( m ) at 20 c, 120hz leakage current dissipation factor ( tan )at 20 c, 120hz characteristics low temperature characteristics at 120hz, impedance ( z ) ratio between the 25 c or 40 c value and 20 c value shall not exceed the values given below. shelf life others the following specifications shall be satisfied when the capacitors are restored to 20 c after exposing them for 1,000 hours at 105 c without voltage applied. the rated voltage shall be applied to the capacitors for a minimum of 30 minutes, at least 24 hours and not more than 48 hours before the measurements. capacitance change: 20% of initial measured value tan (df) : 200% of initial specified value leakage current : 500% of initial specified value satisfies characteristic w of jis c5141 load life the following specifications shall be satisfied when the capacitors are restored to 20 c after subjecting them to the dc rated voltage for the specified test time at 105 c with the rated ripple current applied. the sum of dc voltage and peak ac voltage must not exceed the full rated voltage of the capacitors. case diameter test time 10mm 8,000 hours 12.5mm & above 10,000 hours capacitance change: 20% of initial measured value tan (df) : 200% of initial specified value leakage current : initial specified value at 20 c where i = leakage current ( a ), c = nominal capacitance ( f ) and v = rated voltage ( v ) cv product cv 1,000 cv > 1,000 after 1 minute after 5 minutes i 0.1cv 40 a i 0.04cv 100 a i 0.03cv 40 a i 0.02cv 25 a ripple current multipliers refer to section 4 of the mini-glossary for explanation of ripple current multipliers. frequency (hz ) 120hz 1.00 1.00 1.00 1khz 1.69 1.99 1.23 10khz 2.61 2.60 1.58 100khz 2.87 2.69 1.81 capacitance ( f) 10 f 22 -100 f 220 f rated voltage ( v ) tan (df) 160 0.20 200 0.20 250 0.20 300 0.24 400 0.24 450 0.24 rated voltage ( v ) z( 25 c) /z( 20 c) z( 40 c) /z( 20 c) 160 3 6 200 3 6 250 3 6 300 5 6 400 5 6 450 6 .com .com .com .com 4 .com u datasheet
kmx series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 204 kmx miniature -105 c vb/radial lead unit: mm diagram of dimensions d 10 12.5 16 18 d ' max. d 0.5 d 0.5 d 0.5 d 0.5 l ' max. l 1.5 l 1.5 l 1.5 l 1.5 d 0.6 0.6 0.8 0.8 f 0.5 5.0 5.0 7.5 7.5 f f 15 min. pvc sleeve d ' d vent l ' l d 12.5 ~ 18 10 4 min. gas escape end seal for all case diameters. for optional lead configurations and tape and ammo packaging, refer to the beginning of the miniature section. * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 33 kmx160vb33rm10x20ll 10 20 1.3 210 565 47 kmx160vb47rm12x20ll 12.5 20 0.91 270 725 68 kmx160vb68rm12x25ll 12.5 25 0.63 350 950 68 kmx160vb68rm16x20ll 16 20 0.47 430 970 100 kmx160vb101m16x25ll 16 25 0.27 475 1,280 100 kmx160vb101m18x20ll 18 20 0.31 465 1,180 150 kmx160vb151m10x50ll 10 50 0.77 545 1,020 150 kmx160vb151m16x31ll 16 31.5 0.22 625 1,300 150 kmx160vb151m18x25ll 18 25 0.23 600 1,300 220 kmx160vb221m12x45ll 12.5 45 0.52 740 1,200 220 kmx160vb221m16x31ll 16 31.5 0.22 750 1,300 220 kmx160vb221m18x25ll 18 25 0.23 725 1,300 160 volts 200 volts surge rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c maximum impedance ( ? ) at 20 c, 100khz standard voltage ratings - vb/radial lead 120hz 100khz lead length: ll is standard. case code: see case sizes in tables. capacitance tolerance: m = 20% capacitance value: expressed in microfarads. the first two digits are significant figures, and the third digit indicates the number of zeros for capacitance of 100 f or more. r indicates the decimal point for capacitance less than 100 f (e.g. r33 = .33 f; 3r3 = 3.3 f; 33r = 33 f; 331 = 330 f; 332 = 3,300 f; 333 = 33,000 f). lead configuration: vb = radial lead terminals. dc rated voltage: expressed in volts (e.g. 250 = 250wvdc). series name: indicates basic capacitor design. part numbering system for kmx series when ordering, always specify complete catalog number for kmx series. kmx 250 vb 33r m 12x25 ll .com .com .com .com 4 .com u datasheet
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 205 kmx series kmx miniature -105 c * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c maximum impedance ( ? ) at 20 c, 100khz standard voltage ratings - vb/radial lead 120hz 100khz 10 kmx400vb10rm10x20ll 10 20 2.9 110 180 22 kmx400vb22rm12x25ll 12.5 25 1.3 200 300 22 kmx400vb22rm16x20ll 16 20 0.91 200 600 33 kmx400vb33rm10x40ll 10 40 1.7 215 640 33 kmx400vb33rm16x20ll 16 20 0.91 250 600 47 kmx400vb47rm12x40ll 12.5 40 1.1 280 775 47 kmx400vb47rm16x25ll 16 25 0.73 325 700 47 kmx400vb47rm18x20ll 18 20 0.75 350 750 400 volts 450 volts surge 22 kmx200vb22rm10x20ll 10 20 1.5 165 440 33 kmx200vb33rm12x20ll 12.5 20 0.91 230 590 47 kmx200vb47rm12x20ll 12.5 20 0.91 270 780 68 kmx200vb68rm12x25ll 12.5 25 0.63 350 950 68 kmx200vb68rm16x20ll 16 20 0.47 430 970 100 kmx200vb101m10x50ll 10 50 0.73 430 930 100 kmx200vb101m16x25ll 16 25 0.27 425 1,280 100 kmx200vb101m18x20ll 18 20 0.31 465 1,180 150 kmx200vb151m12x40ll 12.5 40 0.56 615 1,200 150 kmx200vb151m16x25ll 16 25 0.27 580 1,300 220 kmx200vb221m12x55ll 12.5 55 0.39 790 1,420 220 kmx200vb221m18x31ll 18 31.5 0.22 780 1,700 330 kmx200vb331m16x50ll 16 50 0.28 1,020 1,870 470 kmx200vb471m18x50ll 18 50 0.23 1,230 2,180 560 kmx200vb561m18x60ll 18 60 0.18 1,330 2,390 200 volts 250 volts surge 10 kmx250vb10rm10x20ll 10 20 3.5 110 300 22 kmx250vb22rm12x20ll 12.5 20 2.3 185 480 33 kmx250vb33rm12x25ll 12.5 25 1.7 250 630 47 kmx250vb47rm12x25ll 12.5 25 1.7 295 630 47 kmx250vb47rm16x20ll 16 20 1.1 300 750 68 kmx250vb68rm10x50ll 10 50 0.73 340 840 68 kmx250vb68rm16x25ll 16 25 0.78 390 1,000 68 kmx250vb68rm18x20ll 18 20 0.90 385 900 100 kmx250vb101m12x40ll 12.5 40 0.56 500 1,200 100 kmx250vb101m16x31ll 16 31.5 0.63 520 1,400 100 kmx250vb101m18x25ll 18 25 0.63 500 1,345 150 kmx250vb151m12x55ll 12.5 55 0.39 650 1,420 150 kmx250vb151m18x31ll 18 31.5 0.42 640 1,450 220 kmx250vb221m16x50ll 16 50 0.28 820 1,710 220 kmx250vb221m18x40ll 18 40 0.35 820 1,485 330 kmx250vb331m18x50ll 18 50 0.23 1,030 2,140 250 volts 300 volts surge 330 kmx160vb331m16x40ll 16 40 0.35 990 1,540 330 kmx160vb331m18x31ll 18 31.5 0.22 960 1,700 470 kmx160vb471m16x55ll 16 55 0.25 1,220 1,870 560 kmx160vb561m16x60ll 16 60 0.23 1,350 2,140 680 kmx160vb681m18x55ll 18 55 0.20 1,480 2,330 160 volts 200 volts surge 22 kmx300vb22rm12x20ll 12.5 20 2.1 185 270 33 kmx300vb33rm16x20ll 16 20 0.91 250 600 47 kmx300vb47rm10x50ll 10 50 1.2 270 705 47 kmx300vb47rm16x25ll 16 25 0.73 325 700 47 kmx300vb47rm18x20ll 18 20 0.75 350 750 68 kmx300vb68rm12x40ll 12.5 40 1.1 335 895 68 kmx300vb68rm16x31ll 16 31.5 0.49 420 1,100 68 kmx300vb68rm18x25ll 18 25 0.53 400 875 100 kmx300vb101m12x55ll 12.5 55 0.71 435 1,050 100 kmx300vb101m18x31ll 18 31.5 0.40 530 1,170 150 kmx300vb151m16x50ll 16 50 0.51 690 1,400 220 kmx300vb221m18x55ll 18 55 0.32 840 1,610 300 volts 350 volts surge .com .com .com .com 4 .com u datasheet
kmx series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 206 kmx miniature -105 c 68 kmx400vb68rm12x50ll 12.5 50 0.81 335 895 68 kmx400vb68rm16x31ll 16 31.5 0.49 420 1,100 68 kmx400vb68rm18x25ll 18 25 0.53 400 875 100 kmx400vb101m16x40ll 16 40 0.63 540 1,210 100 kmx400vb101m18x35ll 18 35.5 0.34 545 1,250 150 kmx400vb151m16x60ll 16 60 0.41 695 1,490 400 volts 450 volts surge rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c maximum impedance ( ? ) at 20 c, 100khz standard voltage ratings - vb/radial lead 120hz 100khz * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 3.3 kmx450vb3r3m10x20ll 10 20 6.5 60 150 4.7 kmx450vb4r7m12x20ll 12.5 20 3.6 80 200 10 kmx450vb10rm12x25ll 12.5 25 2.5 125 315 22 kmx450vb22rm10x45ll 10 45 2.3 185 520 22 kmx450vb22rm16x25ll 16 25 1.7 210 570 22 kmx450vb22rm18x20ll 18 20 2.1 200 550 33 kmx450vb33rm12x40ll 12.5 40 1.3 235 710 33 kmx450vb33rm16x31ll 16 31.5 1.1 275 620 33 kmx450vb33rm18x25ll 18 25 1.1 280 590 47 kmx450vb47rm12x50ll 12.5 50 0.95 300 845 47 kmx450vb47rm18x31ll 18 31.5 0.93 340 900 68 kmx450vb68rm16x40ll 16 40 0.71 445 985 68 kmx450vb68rm18x35ll 18 35.5 0.71 420 980 100 kmx450vb101m16x60ll 16 60 0.45 570 1,300 150 kmx450vb151m18x60ll 18 60 0.41 690 1,510 450 volts 500 volts surge .com .com .com 4 .com u datasheet
|
